• Українська
  • English

< | >

Current issue   Ukr. J. Phys. 2017, Vol. 62, N 6, p.526-532
https://doi.org/10.15407/ujpe62.06.0526    Paper

Evtukh A.1, Litovchenko V.1, Strikha M.1, Kurchak A.1, Yilmazoglu O.2, Hartnagel H.2

1 V.E. Lashkaryov Institute of Semiconductor Physics, Nat. Acad. of Sci. of Ukraine
(41, Prosp. Nauky, Kyiv 03028, Ukraine; e-mail: anatoliy.evtukh@gmail.com)
2 Department of High Frequency Electronics
(Technische Universit¨at Darmstadt, 64283, Darmstadt, Germany)

Conductive Nanorods in DLC Films Caused by Carbon Transformation

Section: Nanosystems
Original Author's Text: English

Abstract: The influence of diamond-like carbon (DLC) films deposited under various conditions on the electron field emission (EFE) of silicon (Si) tips has been investigated. During the nitrogendoped DLC film deposition, the nitrogen content in a gas mixture is varied from 0% to 45%. In this context, the effective work function is optimized, by reaching the values less than 1 eV. A sharp increase in the emission current at high electric fields and a decrease of the threshold voltage after the pre-breakdown conditioning of a DLC film on Si tips have been measured. At high current densities and the resulting local heating, the diamond-like sp3 phase transforms into a conducting graphite-like sp2 phase. As a result, an electrical conducting nanostructured channel is formed in the DLC film. The diameter of the conducting nanochannel is estimated from the reduced threshold voltage after the pre-breakdown conditioning to be in the interval 5–25 nm. The presence of this nanochannel in the insulating matrix leads to a local enhancement of the electric field and a reduced threshold voltage for EFE. The obtained results can be used for the development of highly efficient field emission cathodes. To explain the experimental EFE results based on a transformation of DLC films and the generation of conduction nanochannels, the changes of the electron affinity (x0) for various carbon structures and impurity point defects have been calculated. The influence of the rehybridization of bonds in various carbon crystal structures on (x0) is shown. The formation of conducting channel arrays in DLC films will allow us to significantly enhance EFE even on flat surfaces without tips.

Key words: diamond-like carbon film, electron field emission, conductive nanorods, carbon nanotube.

References:

  1. V. Litovchenko, A. Evtukh. Vacuum nanoelectronics. In Handbook of Semiconductor Nanostructures and Nanodevices, V. 3. Spintronics and Nanoelectronics. Edited by A.A. Balandin, K.L. Wang (American Scientific Publishers, 2006) p. 153–234.
  2. R.B. Marcus, T.S. Ravi, T. Gmitter, H.H. Busta, J.T. Niccum, K.K. Chin, D. Liu. Atomically sharp silicon and metal field emitters. IEEE Trans. Electron Devices 38, 2289 (1991).
    https://doi.org/10.1109/16.88512
  3. D.W. Branston, D. Stephany. Field emission from metalcoated silicon tips. IEEE Trans. Electron Devices 38, 2329 (1991).
    https://doi.org/10.1109/16.88520
  4. V.G. Litovchenko, A.A. Evtukh, R.I. Marchenko, N.I. Klyui, V.A. Semenovich. The enhanced field emission from microtips covered by ultrathin layers. J. Micromech. Microeng. 7, 1 (1997).
    https://doi.org/10.1088/0960-1317/7/1/002
  5. I. Brodie, C.A. Spindt. Vacuum microelectronics. Adv. Electron. Electron Phys. 83, 1 (1992).
    https://doi.org/10.1016/S0065-2539(08)60006-2
  6. J. Robertson. Structural models of a-C and a-C:H. Diamond Relat. Mater. 4, 297 (1995).
    https://doi.org/10.1016/0925-9635(94)05264-6
  7. F. Demichelis, X.F. Rong, S. Schreiter, A. Tagliaferro, C. De Martino. Deposition and characterization of amorphous carbon nitride thin films. Diamond Relat. Mater. 4, 361 (1995).
    https://doi.org/10.1016/0925-9635(94)05282-4
  8. N.I. Klyui, B.N. Romanyuk, V.G. Litovchenko, B.N. Skarban, V.A. Mitus, V.A. Semenovich, S.N. Dub. Nitrogendoped DLC-films: Correlation between optical and mechanical properties. J. Chem. Vapor Dep. 5 (4), 310 (1997).
  9. R.G. Forbes. Low-macroscopic-field electron emission from carbon films and other electrically nanostructured heterogeneous materials: Hypotheses about emission mechanism. Solid State Electr. 45, 779 (2001).
    https://doi.org/10.1016/S0038-1101(00)00208-2
  10. O. Gr¨oning, O.M. K¨uttel, P. Gr¨oning, L. Schlapbach. Field emission from DLC films. Appl. Surf. Sci. 111, 135 (1997).
    https://doi.org/10.1016/S0169-4332(96)00713-1
  11. A.A. Evtukh, V.G. Litovchenko, N.I. Klyui, R.I. Marchenko, S.Yu. Kudzinovski. Properties of plasma enhanced chemical vapor deposition diamond-like carbon films as field electron emitters prepared in different regimes. J. Vac. Sci. Technol. B 17, 679 (1999).
    https://doi.org/10.1116/1.590617
  12. V.G. Litovchenko, A.A. Evtukh, Yu.M. Litvin, M.I. Fedorchenko. The model of photo- and field electron emission from thin DLC films. Mater. Sci. Eng. A 353, 47 (2003).
    https://doi.org/10.1016/S0921-5093(02)00665-2
  13. J. Robertson. Diamond-like amorphous carbon. Mater. Sci. Eng. R 37, 129 (2002).
    https://doi.org/10.1016/S0927-796X(02)00005-0
  14. O. Gr¨oning, O.M. K¨uttel, P. Gr¨oning, L. Schlapbach. Field emitted electron energy distribution from nitrogencontaining diamondlike carbon. Appl. Phys. Lett. 71, 2253 (1997).
    https://doi.org/10.1063/1.120042
  15. W.A. Harrison. Electronic Structure and the Properties of Solids (Freeman, 1980) [ISBN: 0486660214].
  16. V. Litovchenko. Determination of the base parameters of semiconductor cubic crystals via the lattice constant. Ukr. J. Phys. 50, 1175 (2005).
  17. V. Litovchenko, A. Kurchak, M. Strikha. The semi-empirical tight-binding model for carbon allotropes "between diamond and graphite". J. Appl. Phys. 115, 243705 (2014).
    https://doi.org/10.1063/1.4885060
  18. V. Litovchenko. Analysis of the band structure of tetrahedral diamondlike crystals with valence bonds: Prediction of materials with superhigh hardness and negative electron affinity. Phys. Rev. B 65, 153108 (2002).
    https://doi.org/10.1103/PhysRevB.65.153108